Identification of the stress-strain state and damage of metal structures of building constructions with nanoparticle coatings using the electromagnetic-acoustic method

Автор: Mussa G. Bashirov, Elmira M. Bashirova, Ilvina G. Yusupova, Damir Sh. Akchurin, Rinat T. Yulberdin

Журнал: Nanotechnologies in Construction: A Scientific Internet-Journal @nanobuild-en

Рубрика: Research results of scientists and specialists

Статья в выпуске: 5 Vol.15, 2023 года.

Бесплатный доступ

Introduction. Approximately 20% of accidents in buildings and structures are associated with the destruction of metal structures. Nanocoatings applied to metal structures significantly improve their operational properties, but at the same time make it difficult to use traditional non-destructive testing methods that require access to the surface of the base metal. The quality of the nanocoating is controlled during its formation. To prevent the destruction of metal structures, it is necessary to identify structural heterogeneities of the base metal in micro- and sub-micron sizes, which arise in areas of increased mechanical stress concentration and transform into macrodefects leading to structural failure. Methods and tools are required to non-destructively identify the stress-strain state and damage of the base metal structure through the layer of nanocoating. Electromagnetic-acoustical (EMA) transformation, is considered promising for solving this problem. Existing EMA tools do not fully utilize the potential of EMA conversion, have insufficient sensitivity and the lack of informativity. Methods and materials. For experimental research, we selected widely used in construction structures steels. Research was conducted on the interrelationship of structural alterations in standard samples of metals and the parameters of the electro-magnetic (EMA) transducer under static and cyclic loads. Results. Load diagrams of metal samples were obtained, with accompanying photographs of microstructure in control points, along with their frequency models derived through spectral analysis of the signal from EMA transducer. Discussion. Changes in the stress-strain state of the metal and accumulation of damage in its structure result in a complex interrelated set of changes in mechanical, acoustic, and electro-physical properties, all of which are reflected in the changes in the parameters of the frequency model. Conclusion. Based on the results of the conducted research, the use of a frequency model has been proposed as an integral parameter for identifying the stress-strain state and damage of metal in the equipment. The use of an artificial neural network for analyzing frequency model parameters simplifies the process of identifying the stress-strain state and damage of metal structures and increases its reliability.

Еще

Buildings and structures, metal building structures, nanotechnology, stress-strain state, structural damage, electromagnetic- acoustic transformation, spectral analysis, artificial neural network

Короткий адрес: https://sciup.org/142238328

IDR: 142238328   |   DOI: 10.15828/2075-8545-2023-15-5-482-493

Список литературы Identification of the stress-strain state and damage of metal structures of building constructions with nanoparticle coatings using the electromagnetic-acoustic method

  • Falikman V.R. Nanocoatings in modern construction. Nanotechnologies in construction: scientific online journal. 2021;13(1):5-11. https://doi.10.15828/2075-8545-2021-13-1-5-11
  • Rinkevich A.B., Korkh Y.V., Smorodinsky Y.G. Prospects for the use of non-destructive testing for the diagnosis of nano- and microstructured materials. Defectoscopy. 2010;(1):14-20.
  • Technical regulations on the safety of buildings and structures: Federal Law No. 384-FZ. Electronic fund of legal and regulatory technical documents. Available from: https://docs.cntd.ru/document/902192610.
  • GOST 31937-2011. Buildings and constructions. Rules of inspection and monitoring of the technical condition: interstate standard. Approved and put into effect by Order of the Federal Agency for Technical Regulation and Metrology dated December 27, 2012 N 1984-st: implementation date 2014-01-01. Moscow: Standartinform; 2014.
  • Accidents of buildings and structures on the territory of the Russian Federation in 1993-2002. Bulletins of the Main Inspectorate of the State Architecture and Construction Supervision of Russia.
  • Dmitrieva T.L., Kudrin V.G., Deordiev S.V. Ways to increase the efficiency of research into accidents of steel structures. News of universities. Investments. Construction. Real Estate. 2022;12(1):28–39. https://doi.10.21285/2227-2917-2022-1-28-39
  • Bayburin A.Kh., Stoyakin I.V. Accidents of buildings and structures (lessons from construction accidents). Chelyabinsk: Cicero; 2019.
  • Eremin K.I. Systematization of scientific research in the field of integrated safety of construction sites. Materials of the round table “Integrated safety in construction.” Available from: https://profi.erzrf.ru/upload/iblock/97d/Eremin-K.I._-Sistematizatsiya-nauchnykh-issledovanii_-v-oblasti-kompleksnoi_-bezopasnosti-v-stroitelstve.pdf.
  • Eremin K.I., Matveyushkin S.A. Features of examination and non-destructive testing of building metal structures. Prevention of accidents in buildings and structures. Available from: https://prevdis.ru/osobennosti-ekspertizyi-nerazrushayushhego-kontrolya-stroitelnyh-metallicheskih-konstruktsij/.
  • GOST R 56542-2015. Non-destructive testing. Classification of types and methods. Electronic fund of legal and regulatory documents. Available from: https://docs.cntd.ru/document/1200123257.
  • Dubov A.A. Fundamental distinctive features of the method of magnetic memory of metals and testing devices in comparison with known magnetic methods of non-destructive testing. Control. Diagnostics. 2003;(12):27-29.
  • Yakubovsky R.Y., Bulanov I.A., Oliper I.A., Salakhov R.G., Kazakov A.A. Methods for examining metal, reinforced concrete and stone structures. Young scientist. 2015; 23 (103): 283-287. Available from: https://moluch.ru/archive/103/23680.
  • Arefiev Y.V., Bezlyudko G.Ya., Shalygo A.A. New in diagnostics of the technical condition of metal building structures. Stroymetall. 2014;(42):2-6.
  • GOST R 52330–2005. Non-destructive testing. Monitoring the stress-strain state of industrial and transport facilities. General requirements. Available from: https://docs.cntd.ru/document/1200039616.
  • GOST R 53966–2010. Non-destructive testing. Monitoring the stress-strain state of structural materials. General requirements for the procedure for selecting methods. Available from: https://docs.cntd.ru/document/1200082717.
  • MDS 53-2.2004. Diagnostics of steel structures. Available from: https://docs.cntd. ru/document/1200030802.
  • GOST R 52731-2007. Non-destructive testing. Acoustic method for monitoring mechanical stress. General requirements. Available from: https://docs.cntd.ru/document/1200051032.
  • GOST R ISO 24497-2-2009. Non-destructive testing. Metal magnetic memory method. Part 2. General requirements. Available from: https://docs.cntd. ru/document/ 1200075955.
  • GOSTR 58599-2019. Technical diagnostics. Diagnostics of steel structures. Magnetic coercimetric method. General requirements. Available from: https://docs.cntd.ru/document/1200168809/titles.
  • Bashirov M.G., Bashirova E.M., Yusupova I.G., Dratsky V.O., Murtazina A.I., Kvachinsky S.A. Modeling and experimental study of the influence of mechanical stresses and metal damage of oil and gas equipment on the parameters of electromagnetic-acoustic conversion. Oil Gas Bus. 2023;21(1):183-194.
  • Uglov A.L., Khlybov A.A., Bychkov A.L., Kuvshinov M.O. On non-destructive testing of residual stresses in axisymmetrically shaped parts made of steel 03N17K10V10MT. Bull IzhSTU Named After MT Kalashnikov. 2019;22(4):3-1.
  • Muravyov V.V., Budrin A.Y., Sintsov M.A. Structoscopy of heat-treated steel rods based on the speed of propagation of Rayleigh waves. Intelligent Syst Prod. 2020;18(2):37-20.
  • Volkova L.V., Muravyova O.V., Muravyov V.V. Unevenness of acoustic anisotropy of rolled steel plates. Steel. 2021;(5):36-41.
  • Muravyova O.V., Volkova L.V., Muravyov V.V., Sintsov M.A., Myshkin Y.V., Basharova A.F. Sensitivity of the electromagnetic-acoustic multiple shadow method using Rayleigh waves when inspecting oil pipes. Defectoscopy. 2020;(12):48-57.
  • Ducousso M., Reverdy F. Real-time imaging of microcracks on metallic surface using total focusing method and plane wave imaging with Rayleigh waves. NDT E Int. 2020;116:102311. https://doi.org/10.1016/j.ndteint.2020.102311
  • Trushkevych O., Edwards R.S. Characterisation of small defects using miniaturised EMAT system. NDT E Int. 2019;107:102140. https://doi.org/10.1016/j.ndteint.2019.102140
  • Zhai G, Li Y, Qin Y, Liu Y. Design Method of Multiwavelength EMATs Based on Spatial Domain Harmonic Control. IEEE Trans Ultrason Ferroelectr Freq Control. 2021;68(6):2259-2270. https://doi.org/10.1109/TUFFC.2021.3055871
  • Guo W., Yu Z., Chui H.C., Chen X. Development of DMPS-EMAT for Long-Distance Monitoring of Broken Rail. Sensors (Basel). 2023;23(12):5583. https://doi.org/10.3390/s23125583
  • Bashirov M.G., Khusnutdinova I.G. The use of electromagnetic-acoustic method for estimating the stressstrain state of the metallic elements of power equipment. Key Eng Mater. 2017; 743:463–467. https://doi.org/10.4028/www.scientific.net/KEM.743.463
  • Bashirov M.G., Bashirova E.M., Khusnutdinova I.G. The dynamic identification of the technical condition of pipelines on the basis of the analysis of the temporal characteristics of electromagnetic-acoustic signal. IOP Conf Ser Mater Sci Eng. 2019; 12042. http://doi.org/10.1088/1757-899X/511/1/012042
  • Khusnutdinova I.G., Bashirov M.G., Bashirova E.M., Prakhov I.V. Device for non-contact monitoring of the stress-strain state and level of damage of metal structures. Russian Federation Patent N 2016150488. 2017.
  • Bashirov M.G., Bashirova E.M., Bashirov R.A., Khusnutdinova I.G. Assessment of the stress-strain state and damage of metal structures using the electromagnetic-acoustic method. Certificate of state registration of computer programs No. 2018617490.
  • Bashirov M.G., Minlibaev M.R., Safin E.M. Theoretical Analysis of Wave Electromagnetic-Acoustic Processes in a Medium During the Operation of an Electromagnetic-Acoustic Transducer. In: Proc of International Multi-Conference on Industrial Engineering and Modern Technologies (FarEastCon). 2020; 1-4. http://doi.org/10.1109/FarEastCon50210.2020.9271089
Еще
Статья научная